產品說明 Description

由氯化橡膠、顏料、增塑劑、添加劑、溶劑等組成，漆膜堅韌，具有優良的耐候性，還有一定的耐化學藥品性能。

It is made up of chlorinated rubber, pigment, plasticizer, additives, solvents etc., with strong film. It has good weatherability and some resistance to chemical substances.

 

設計用途 Use

船舶、集裝箱、港口機械及各種鋼鐵結構及混凝土作面漆。

As finishing paint for ships, containers, harbor machinery, every kind of steel structures and concrete.

 

物理參數 Physical Parameter

顏色：白色 奶油黃 海藍色 灰綠色 中綠色 淺灰色 大紅色 鐵紅色 銀白色 也可按用戶指定色卡定制各色。

光澤：半光

理論涂布率：10m2/千克

比重：約1.00-1.25

干燥時間：23±2℃：表干≤2h,實干≤8h

閃點：38℃

貯儲期：12個月

 

Color: White, Butter Yellow, Ocean Blue, Grayish-green, Medium Green, Light Grey, Bight Red, Iron-red, Silver-white, or customer colors as per the specific color chip.

Gloss: Semi-light

Theoretical Spreading Rate: 10m2 /kg

Specific Gravity: Approx. 1.00-1.25

Flash Point：38℃

Storage Life: 12 months

 

施工說明 Description of Application

混合配比: 單罐裝

熟化時間: 打開攪勻即可使用

適用期: 無限制

施工方法: 高壓無氣噴涂 有氣噴涂 手工刷涂 輥涂

稀釋劑: 氯化橡膠涂料稀釋劑

Mixture Ratio: Single Pot

Maturing Time: Ready to use after even stirring

Pot Life: no limits

Application Method: High Pressure Airless Spraying, Air Spraying, Manual Brush Coating and Roller Painting.

Thinner: Chlorinated Rubber Paint Thinner

 

高壓無氣噴涂 High Pressure Airless Spraying	有氣噴涂 Air Spraying	手工刷涂、輥涂 Manual Brush Coating and Roller Painting
5%	10%	3%
0.4-0.5mm	2.0-2.5mm	-
12-15MPa	0.3-0.4MPa	-

 

 

 

 

 

最大稀釋量

Max. Usage of Thinner

噴孔 Spray Orifice

噴出壓力 Pressure When Spraying

工具清洗 氯化橡膠涂料稀釋劑 Tool Cleaning: Chlorinated Rubber Paint Thinner

漆膜厚度 濕膜：125μm 干膜35μm

Film Thickness: Wet Film:125μm; Dry Film: 35μm

涂裝間隔　Painting Interval

 

底材溫度 Temperature of Substrate Materials	0℃	20℃	30℃
最短 Min. Time	24h	8h	6h
最長 Max. Time	無限制 Unlimited

　　

表面處理　Surface Treatment

如前道漆面已經污染，應用適當的方法除去油脂、灰塵，也可本漆稀釋劑擦洗。

If the former coating is tainted, grease and dust should be cleared away by appropriated ways. Also, thinner for this paint can be used for cleaning.

 

施工條件 Application Conditions

底材溫度須高于露點以上3℃相對濕度須小于85%。

The temperature of substrate materials should be 3℃ above the dew point, and relative humidity should be less than 85%.

前道配套涂料 氯化橡膠鋁粉厚漿型防銹漆

氯化橡膠鐵紅厚漿型防銹漆

氯化橡膠云鐵防銹漆

環氧鐵紅聚脂防銹漆等

Preceding Coats: Chlorinated Rubber Powdered Aluminum High Build Anti-rust Paint, Iron-red Chlorinated Rubber High Build Anti-rust Paint, Micaceous Iron Chlorinated Rubber Anti-rust Paint, Iron-red Epoxy Oxide Polyester Anti-rust Paint etc.

 

包裝規格 Packing Specification

20升容器20公斤

20L Container, 20kg

 

安全 Safety

避免長期吸入溶劑蒸汽或漆霧，皮膚、眼睛不得接觸本品，在狹窄或空氣不流通處施工，必須提供強力通風，施工時應配防護用具。

To avoid the long-term inhalation of solvent vapor or paint mists. To avoid contacts with skin and eyes. Forced ventilation must be provided when applying paints in confined space or stagnant air. Protective appliance is required during application.

 

附注 Notes

上述的干濕膜厚度都是指高壓無氣噴涂時的指標;

本說明有關數據是在實驗室取得，實際產品可能與之略有不同;

以上數據如有改變，以本公司最新說明書為準，恕不另行通知。

The above index of dry and wet film thickness is under high pressure airless spraying. All data in this description is obtained in laboratory and slight variation may occur during actual use. The above specification and description are subject to the change without notice.

 

以上最終解釋權歸南京東頂化工有限公司所有